Help! Yellow clone starts on full choke, runs 20 seconds, s

DrChip

Cleaned jet, tried everything carb wise. At the extent of my knowledge.

What else could it be? Slipped timing, by flywheel key part sheared

Frustrated! c
_________________
"kart racing since 1958, was and still the best bank for the buck in motorsports"

Badbandit12 · Posted: Tue Nov 06, 2012 9:36 pm Post subject:

Check the fuel pump for any air leaks, if thats fine then try pulse line . If still no fix then check coil wire at the coil , make sure it's got a good connection . Hope this helps .

DrChip · Posted: Tue Nov 06, 2012 9:38 pm Post subject:

TY c
_________________
"kart racing since 1958, was and still the best bank for the buck in motorsports"

John Wehrheim · Posted: Wed Nov 07, 2012 8:03 am Post subject:

Which fuel pump do you have? Is the carb getting full fuel or is their a lot of air in the line. It is either your pump or carb. I think it's your carb. I believe you haven't raced much recently. The fuel can clog the holes in the emulsion tube. Check and clean the holes in emulsion tube and the main jet. Also I would take the fuel float and needle out. And remove the small bowl where you have the fuel on/off lever. Clean with break clean all the holes in the carb.
_________________
John
Board of Directors
Sr. 2 Cycle Director

DrChip · Posted: Wed Nov 07, 2012 9:37 am Post subject:

John-This is not my razor, this is my loaner kart. I did have probs with the razor, cleaned the jet and all is well.

Lent the laner kart to someone and they could not get it started. They cleaned some things but not sure what all.

I tried starting it and having the same symptoms. HAve not had time to get tio it but will soon. c
_________________
"kart racing since 1958, was and still the best bank for the buck in motorsports"